Mason Sand for Patios in Ocoee, TN

If you need gravel and aggregate delivery in Ocoee, TN, Tennessee Rock Supply stocks the materials local crews ask for by name. Crusher run leads the list, because it sets the base under most patios and drives around Polk County. So does the grey cherty clay that sits under a lot of this ground.

Materials for Ocoee Projects

The bedding course is what keeps an Ocoee patio flat. Get that layer right and the pavers stay flat through wet winters and hot summers. Get it wrong and you are resetting stone within a season.

For the bedding itself, screenings are the standard choice. The fine, angular grit locks pavers and flagstone in place at a depth of about an inch. They also work under path surfaces and as a leveling course where you want a firm, tight finish.

Sand matters just as much on flatwork and joints. Mason sand packs into paver joints and beds brick and block. Washed sand goes under slabs and bedding courses where clean, free-draining material counts.

Below the bedding, base is what carries the load. Crusher run is the Tennessee driveway and base stone, with the fines left in so it compacts hard. Where a spec calls for graded base under heavier pads, mineral aggregate base is the graded base stone to order.

Drainage details finish the job. #57 stone and #67 stone handle French drains, downspout runs and drainage behind a retaining wall. Drain rock covers the same ground in a coarser size.

Ground and Conditions in Ocoee

Ocoee patios usually fail because the base under them is too thin. Set pavers on an inch or two of stone over clay and the corners drop the first wet spring, because the clay underneath never drains and never stops moving.

Give the patio a deeper base and a way for water to drain out. Excavate deep enough to carry a compacted base under the bedding, then keep water out of the profile. In the limestone and dolomite valleys, sinkholes and springs send runoff underground. On the slower clay and shale ground, storm water runs across the surface to the creeks instead.

That runoff matters on your site too. Storm water off the ridge slopes scours creek banks and cuts into bare clay on cleared ground. If your patio sits near a slope or a ditch, plan a drainage layer and armor the outlet with rip rap.

Timing is practical, not fussy. Late winter and spring are the wettest stretch, and flash flooding peaks from late spring into summer. Saturated clay and high creeks delay base work far more often than frozen ground does. Frost is shallow on the valley floors, though the nearby ridges run colder and see more snow.

Delivery to Ocoee and the Surrounding Area

Ordering online starts with a quantity. Decide whether your job is easier to figure in tons or in cubic yards, then convert before you check out. Tons are the weight of the material. Yards measure the volume it fills.

For a bedding course, a simple estimate works. Multiply the patio length by its width, then by the bedding depth in feet, and divide by 27 for cubic yards. Screenings and sand weigh differently from stone, so enter the bedding depth and pick the product in the calculator to size the load.

Bulk delivery to a site in Ocoee means a truck that needs room to turn and a firm spot to dump. Point us to a driveway or a cleared pad, not soft ground. We also deliver across Polk County, including Benton, Delano, Copperhill, Farner and Old Fort.

Questions Ocoee Buyers Ask

What gravel is best for a driveway in Ocoee?

Crusher run is the standard. It packs into a hard, stable surface because the fines stay in the mix, which suits the cherty clay ground common in this part of Polk County. Top it with clean stone if you want a tidier look. For heavier loads, order graded base stone under the surface course.

How much material will my project need?

Measure the area, decide your depth, and convert to cubic yards or tons. Bedding sand and screenings are usually figured at about an inch deep. Base stone runs much deeper and is compacted in lifts. Our online calculator handles the conversion so you can order the right amount in one trip.

Size Your Patio Order and Place It

Use the calculator to turn your patio dimensions and bedding depth into cubic yards, then check that figure against tons before you order. If the numbers look close, order a little extra for compaction and waste. Send your order through and we will schedule bulk delivery to your Ocoee site.